T04e T3/t4 A/r. 63 57 Trim 5-bolt 400+hp Stage III Boost Turbo Charger+controller

  

63 57 TRIM 5-BOLT 400+HP STAGE III BOOST TURBO CHARGER+CONTROLLER. High Compression/ Boosting Turbocharger: The objective of a turbocharger is to improve the engine's volumetric efficiency by solving the amount of air flow into the combustion chamber limitation. This ultimately results in an increased torque and output of the engine.

A naturally aspirated automobile engine uses only the downward stroke of a piston to create an area of low pressure in order to draw air into the cylinder through the intake valves. The pressure in the atmosphere is about 1 atm (approximately 14.7 PSI), so there ultimately will be a limit to the pressure difference across the intake valves.

This will also limit the amount of airflow entering the combustion chamber. Since the turbocharger increases the pressure at the point where air is entering the cylinder, a greater mass of air (oxygen) will be forced in as the inlet manifold pressure increases. The additional air/oxygen flow makes it possible to maintain the combustion chamber pressure and fuel/air load even at high engine revolution speeds, increasing the power and torque output of the engine. 30psi Turbo Boost Controller: A manual boost controller is a simple mechanical and pneumatic control to allow some pressure from the wastegate actuator to escape or bleed out to the atmosphere or back into the intake system. This can be as simple as a T-fitting on the boost control line near the actuator with a small bleeder screw.

The screw can be turned out to varying degrees to allow air to bleed out of the system, relieving pressure on the wastegate actuator, thus increasing boost levels. These devices are popular due to their negligible cost compared to other devices that may offer the same power increase. Capable of Boosting Horse Power up to 300+ BHP. Minimum Estimated Power Gain: 75 - 100 HP. High Quality Material, Cast Housing with Durable Steel. 3.00"/ 2.00". 50.50 / 76.00. 65.50 / 55.90.

1 x Turbo Boost Controller. Hardware as Shown in the Picture Above. Professional Installation is Highly Recommended. Installation Instruction is NOT Included.

Video will open in a new window. DOMESTIC LOWER 48 US STATES. We are not responsible for incorrect or undeliverable addresses. Some of the packages cannot be delivered to a PO Box. Package will be held until a valid physical address is provided.

For emissions related items, please check with your local jurisdiction for emission specific requirements before purchasing. All items do not come with installation instruction unless otherwise specified.

The item "T04E T3/T4 A/R. 63 57 TRIM 5-BOLT 400+HP STAGE III BOOST TURBO CHARGER+CONTROLLER" is in sale since Saturday, March 28, 2015. This item is in the category "eBay Motors\Parts & Accessories\Car & Truck Parts\Turbos, Nitrous, Superchargers\Turbo Chargers & Parts". The seller is "speed_daddy" and is located in Rowland Heights, California. This item can be shipped worldwide.

• Brand: Speed Daddy
• Manufacturer Part Number: SDD-TBCT04E63+BCRD
• Color: Metallic
• Materials: Cast Iron/Steel Turbo Housing/ Aluminum Controller
• Placement on Vehicle: Front,Rear,Left,Right
• Surface Finish: Cast
• UPC: DOES NOT APPLY
• Intake Inlet/ Outlet: 3.00"/ 2.00"
• Inlet / Outlet Diameter: 3" / 2"
• Compressor A/R: 0.5
• Compressor Inducer /Exducer (MM): 50.50 / 76.00
• Compressor Trim: 55
• Exhaust (Downpipe) Flange: Standard T3 5-Bolt
• Exhaust (Turbo Manifold) Flange: Standard T3/ T4 4-Bolt
• Turbine A/R: 0.63
• Turbine Inducer / Exducer (mm): 65.50 / 55.90
• Turbine Trim: 73
• Fitment Type: Performance/Custom